Hardware Information

Testing Flyback Transformer - How to Test and When to Replace It


Nowadays, more and more monitor comes in with flyback transformers problems. Testing flyback transformers arenot difficult if you carefully follow the instruction. In many cases, the flyback transformer can become short circuit after using not more than 2 years. This is partly due to bad design and low quality materials used during manufactures flyback transformer. The question is what kind of problems can be found in a flyback transformer and how to test and when to replace it. Here is an explanation that will help you to identify many flyback transformer problems.

There are nine common problems can be found in a flyback transformer:

a) A shorted turned in the primary winding.

b) An open or shorted internal capacitor in secondary section.

c) Flyback Transformer becomes bulged or cracked.

d) External arcing to ground.

e) Internal arcing between windings.

f) Shorted internal high voltage diode in secondary winding.

g) Breakdown in focus / screen voltage divider causing blur display.

h) Flyback Transformer breakdown at full operating voltage (breakdown when under load).

i) Short circuit between primary and secondary winding.

Testing flyback transformer will be base on (a) and (b) since problem (c) is visible while problem (d) and (e) can be detected by hearing the arcing sound generated by the flyback transformer. Problem (f) can be checked with multimeter set to the highest range measured from anode to ABL pin while (g) can be solved by adding a new monitor blur buster (For 14' & 15' monitor only.) Problem (h) can only be tested by substituting a known good similar Flyback Transformer. Different monitor have different type of flyback transformer design. Problem (i) can be checked using an ohm meter measuring between primary and secondary winding. A shorted turned or open in secondary winding is very uncommon.

What type of symptoms will appear if there is a shorted turned in primary winding?

a) No display (No high voltage).

b) Power blink.

c) B+ voltage drop.

d) Horizontal output transistor will get very hot and later become shorted.

e) Along B+ line components will spoilt. Example:- secondary diode UF5404 and B+ FET IRF630.

f) Sometimes it will cause the power section to blow.

What type of symptoms will appear if a capacitor is open or shorted in a flyback transformer?

Capacitor shorted

a. No display (No high voltage).

b. B+ voltage drop.

c. Secondary diode (UF5404) will burned or shorted.

d. Horizontal output transistor will get shorted.

e. Power blink.

f. Sometimes power section will blow, for example: Raffles 15 inch monitor.

g. Power section shut down for example: Compaq V55, Samtron 4bi monitor.

h. Sometimes the automatic brightness limiter (ABL) circuitry components will get burned.

This circuit is usually located beside the flyback transformer. For example: LG520si

Capacitor open

a. High voltage shut down.

b. Monitor will have 'tic - tic' sound. Sometimes the capacitor may measure O.K. but break down when under full operating voltage.

c. Horizontal output transistor will blow in a few hours or days after you have replaced it.

d. Sometimes it will cause intermittent "no display".

e. Distorted display i.e., the display will go in and out.

f. It will cause horizontal output transistor to become shorted and blow the power section.

How to check if a primary winding is good or bad in a Flyback Transformer?

a) By using a flyback/LOPT tester, this instrument identifies faults in primary winding by doing a 'ring' test.

b) It can test the winding even with only one shorted turned.

c) This meter is handy and easy to use.

d) Just simply connect the probe to primary winding.

e) The readout is a clear 'bar graph' display which show you if the flyback transformer primary winding is good or shorted.

f) The LOPT Tester also can be used to check the CRT YOKE coil, B+ coil and switch mode power transformer winding.

NOTE: Measuring the resistance winding of a flyback transformer, yoke coil, B+ coil and SMPS winding using a multimeter can MISLEAD a technician into believing that a shorted winding is good. This can waste his precious time and time is money.

How to diagnose if the internal capacitor is open or shorted? By using a normal analog multimeter and a digital capacitance meter. A good capacitor have the range from 1.5 nanofarad to 3 nanofarad.*

1) First set your multimeter to X10K range.

2) Place your probe to anode and cold ground.

3) You must remove the anode cap in order to get a precise reading.

4) Cold ground means the monitor chassis ground.

5) If the needle of the multimeter shows a low ohms reading, this mean the internal capacitor is shorted.

6) If the needle does not move at all, this doesn't mean that the capacitor is O.K.

7) You have to confirm this by using a digital capacitance meter which you can easily get one from local distributor.

8) If the reading from the digital capacitance meter shows 2.7nf, this mean the capacitor is within range (O.K.).

9) And if the reading showed 0.3nf, this mean the capacitor is open.

10) You have three options if the capacitor is open or shorted.

- Install a new flyback transformer or

- Send the flyback transformer for refurbishing or

- Send the monitor back to customers after spending many hours and much effort on it.

* However certain monitors may have the value of 4.5nf, 6nf and 7.2nf. Note: Sometimes the internal capacitor pin is connected to circuits (feedback) instead of ground.

Tv rca flyback transformer circuits usually do not have a internal capacitor in it.

If you have a flyback diagram and circuits which you can get it from the net, that would be an advantage to easily understand how to check them.

Jestine Yong is a electronic repairer and a writer. For more electronic repair articles please visit his website at http://www.noahtec.com/electronic-repair-articles.htm


MORE RESOURCES:

Hifn to Showcase Industry's First Hardware-Accelerated Storage ...
MarketWatch - 13 hours ago
Hifn will be demonstrating its new hardware-accelerated data de-duplication product. As the first vendor to deliver a hardware-accelerated data ...
InMage expands support for XenServer, Hyper-V in DR-Scout Search Storage
InMage Systems Announces New Version of Flagship DR-Scout Disaster ... International Business Times
InMage Systems Announces New Version of Flagship DR-Scout Disaster ... MarketWatch
all 22 news articles


Negotiating with your hardware vendor 101
ZDNet - 12 hours ago
Squeezing the most out of technology budgets seems to be a running theme these days, but customers frequently give up leverage in negotiating hardware deals ...
CEOs freak out; IT preps a do-over ZDNet
IT warning: Turbulence ahead ZDNet
all 4 news articles


Lockheed Martin Delivers Key Hardware for US Navy's Mobile User ...
MarketWatch - 10 hours ago
SUNNYVALE, Calif., Oct 13, 2008 /PRNewswire via COMTEX/ -- Lockheed Martin (NYSE: LMT) announced today the successful delivery of the core structure with an ...


Jackson's Hardware cited as top workplace
Marin Independent-Journal, CA - 2 hours ago
Employee-owned Jackson's Hardware in San Rafael is one of the 15 best small workplaces in the United States, the Wall Street Journal reported Monday. ...
Where small is beautiful San Francisco Chronicle
all 2 news articles


Fire consumes Ace Hardware store
Enterprise-Record, CA - 9 hours ago
ORLAND — A fire that reportedly broke out at about 2 am today gutted the Ace Hardware store, located on Fifth Street. Part of the rear of the store, ...


Jordan's hardware helper dies in motorcycle crash
Jordan Independent, MN - 7 hours ago
A resident of Cologne, Thoele worked at the Jordan Ace Hardware store. Thoele, driving the Harley Davidson motorcycle with Lofquist, laid the motorcycle on ...


MLS - Major League Soccer

Hoops look to add hardware
MLS - Major League Soccer, NY - 4 hours ago
By Steve Hunt / MLSnet.com Staff FRISCO, Texas -- Outside of league play this season, FC Dallas has won the USA/Brazil Challenge with South American partner ...


QSGI Certified as a Microsoft(R) Authorized Refurbisher
IT News Online, India - 12 hours ago
QSGI provides a full suite of information technology services to help corporations and governmental agencies better manage hardware assets, ...


Cost-cutting, greater efficiencies to be topics at SNW
Computerworld, MA - 22 hours ago
HP has added an option for users -- new hardware encryption for its HP StorageWorks XP24000 and XP20000 disk arrays. The enhancements can reduce the risk of ...
HP Strengthens Security Portfolio With New Disk Encryption and Key ... MarketWatch
all 24 news articles


West golfers set sights on State AA hardware
Billings Gazette,  USA - 17 hours ago
By ED WEST There could be a couple of additions to the Billings West trophy case if the boys and girls golf teams can put things together this week in ...

Hardware - Google News

home | site map
© 2006