| |
| |
|
Home Improvement Information |
|
|
|
Single Pane Glass Repair in an Aluminum Frame, Part 2
This week we are going to continue our series on single pane window glass repair. Let's talk about broken glass in a fixed window, usually referred to as a picture window. The most common type will have metal stops on the outside, around all four edges of the window glass. Sometimes these stops will be held in place with screws, and other times there will be aluminum stops that snap in place. In some rare instances there will be a rubber material in place of metal. If you have the screw type, you remove all of the screws and each piece will come out. If you have the metal snap in stops, carefully pry the stop from the frame using a small, flat screwdriver or a putty knife. You want to start in a corner and work along the stop until it comes out. Don't pry too much because the stops can bend very easily. If you have the rubber type, pry a corner away using the screwdriver, grab it with your fingers, and pull out the rubber. The glass shouldn't fall out because there is a glue or tape on the edge, holding the glass in place. From here, You can get your measurements for the new piece of glass. The glass edges will be exposed, and you can hook your tape measure to the edge and get your width and height. If there is a hole in the glass, measure the glass thickness. If there isn't a hole, put on some gloves and carefully push on the glass where the crack is located. This will expose the edge so you can measure it. When you go to get the new glass, you're going to need a tube of silicone to replace the glue or tape holding the glass in place. Once you get the glass home, you need to remove the old glass. Go inside and cut between the glass and frame using a utility knife with a new blade. This will cut away the silicone or tape that is holding the old glass. Be sure to wear heavy gloves during this process to avoid getting cut. Start at the top and cut across from one corner to the other. Then cut down one side, from top to bottom. Do the other side the same way. At this point the glass should fall out. You should place a tarp or sheet under the window to catch the glass as it falls out. Using a stiff putty knife, scrape off the old silicone or tape from the frame. If there were setting blocks on the bottom, be sure to reuse them. They act as shims to raise the glass off the bottom. Now run a bead of silicone about 3/16" thick around the perimeter of the opening. Grab your new glass on the sides, angle the bottom in and the top out, set the glass on the setting blocks, then slowly raise the glass up into place. Push just hard enough that all four edges of the glass contact the silicone, but not so hard that the glass makes contact with the metal frame. Install your outside stops. Don't clean the glass for 24 hours so the silicone can set up. Next week I will continue this series on window glass repair. John Rocco has been installing replacement windows since 1978. To learn more, visit How To Install Windows
MORE RESOURCES:
Home-Improvement - Google News |
|
|
|
RELATED ARTICLES
Planning Permission Tips UK - Rights of Light to Adjoining Neighbours Windows - What You Should Know Rights of light - What a minefield this topic is when developing or extending a property. This is potentially one of the most subjective Planning issues their is. CCTV for the Home Securing your property is one of the growing domestic issues in the UK today. Some research suggests that at least one home is broken into every minute. Planning Permission Tips UK - Agricultural Plots of Land for Sale - The Latest Mug Punter Scam? The first part of most years brings a flurry of trade shows aimed at the public & trade alike such as The Ideal Home Show, Interiors & just recently the Building Exhibition at the NEC. It never ceases to amaze me the amount of new gadgets & Gizmos (along with the usual tat) that companies invent for our consumption. Home Air Filters: Knowing Which One to Choose Since air filters are one of the bests tools for eradicating allergens from your home, more people are using them than ever before. The trick is to find the one that works best for you, depending upon your specific needs. How to Troubleshoot Video Problems Few things can be as frustrating as picture problems. You get your system all ready to go, flip the switch, and WHAM! One or more channels look terrible. Conservatory Planning Permission in the UK It is quite unusual in the UK for a new conservatory to require planning permission. However, as we shall continually state in this article it is always sensible to check with your local authority. Architect or Building Designer - Who Do You Choose? Thinking of building a new home or complex? Will you use an architect or a building designer?Both are involved in the design of buildings - their appearance, layout, structure, and so on. But what's the difference?The simplest difference is a legal one. Five Ways to Create a Healthy Home Have you ever thought of your home as being healthy or unhealthy? While the concept of a healthy home may be new to some of us, it is steadily gaining popularity with homeowners. A healthy home can include a number of elements from building materials used to construct your home to using non-toxic cleaning products. Removing Your Old Wood Double Hung Windows Last week I told you how to measure your wood window openings to properly order your new vinyl replacement windows. This week I'm going to explain how to remove your old windows. An Introduction to Waterproofing Systems Many homeowners find it necessary to invest in a waterproofing system for their home, especially if their home has a basement or cellar. In modern home developments, it is often required by state or local regulations to have a waterproofing system installed before the completion of the home. At Last You Can Customize Your Pegboard As Much As You Want Customizable metal pegboard is set to revolutionise utensil storage. For forty years the limitations of fibreboard has narrowed our imagination in utensil storage. The Art of Power Washing Decks Since the Environmental Protection Agency (EPA) started banning the use of pressure treated wood due to chromated copper arsenate (CCA), most people have decided to seal their wood decks as the EPA suggests to prevent the arsenic from leaching into the soil. Most homeowners use local companies to pressure wash their decks and siding to save valuable time and the expense of rental equipment and some prefer to do the job themselves on a hot summer day. Dual Pane Window Glass Repair For the past few weeks, I have been explaining how to repair a broken window pane in your home. But, what if you have dual pane windows? Is the process the same? Well, pretty much, except for a couple of variations. The Importance of Bedroom Design in a Home Decoration Project. A home is a place where we live, spend most of our lives, with family members and our loved ones.A bedroom design project includes a careful study of the surrounding of the entire home. How to Collect Physical Mold Growth Samples for Low-Cost Mold Laboratory Identification of Mold Spec How to Collect Physical Mold Growth Samples for Low-Cost Mold Laboratory Identification of Mold SpeciesVANCOUVER, CANADA. Many property owners, apartment landlords, renters, employers, and employees want to know, and need to know, the precise identities of the various mold species infesting their moldy house, rental unit, or place of employment, according to Phillip Fry, Certified Mold Inspector and author of the book Do-It-Best-Yourself Mold Prevention, Inspection, Testing, & Remediation. Heat Up the Hot Tub from 20,000 Feet Homeowners are getting high-tech when it comes to controlling the appliances in their homes, but they insist the control systems are reliable, convenient and easily understood. Technology isn't fun to use if you feel like you need a master's degree in engineering to make things work. Plastic Applied to the Picnic Table? There are many styles of picnic tables on the market, but what kind of material is best for durability and safety? Powder coating has been an accepted coated finish for years and there are several reasons why. The coating look great, you can have most any color you want, they are friendly to the environment and efficient to produce. Bathroom Wall Cabinets - Create Extra Space with a Touch of Style! Is your bathroom looking cluttered? How about fitting new bathroom wall cabinets to store all your toiletries and appliances? These days we all tend to have a myriad of lotions and potions to keep us looking our best, but the result of having so many bottles in our bathrooms is that our bathroom vanity surfaces can become untidy and crowded. Adding more bathroom storage cabinets can give you welcome space to store all your accessories, leaving your surfaces tidy and clutter free!The traditional bathroom medicine cabinet fitted above the sink is no long used just for storing medicines. Replacement Windows and Double Glazing - Essential Buyers Tips Welcome to my essential tips for replacemnent windows and double glazing buyers. Apart from the first tip (which I consider most important) the tips are not in any particular order. Lighting up Your Life You are visiting a friend that has just had a beautiful kitchen remodel done. It is a lovely kitchen with stunning granite countertops and a sharp looking tile backsplash.
|
| home | site map |
| © 2006 |
